行業資訊
濟南水穩料施工時注意事項
來源：http://m.seatostar.com/ 日期：2022-05-18
水穩料主要由粒料和灰漿體積組成。由水泥、石灰、石膏等膠凝材料加水拌合而成的漿狀混合料，用于粉刷或灌縫。那么濟南水穩料施工時注意事項是什么呢？
Water stabilized material is mainly composed of granular material and mortar volume. A slurry mixture made of cement, lime, gypsum and other cementitious materials mixed with water, which is used for painting or joint filling. So what are the precautions for the construction of water stabilized materials in Jinan?
攪拌設備的選擇
Selection of mixing equipment
攪拌設備的好壞直接影響到混合料的攪拌質量，而攪拌設備質量好壞的關鍵在于能否保證骨料、粉料、水等物料的混合比例精度。本標段采用WBC300型穩定土植物攪拌設備。設備采用電磁調速系統，能更好地保證各種物料的混合比，混合均勻，性能穩定。
The quality of mixing equipment directly affects the mixing quality of mixture, and the key to the quality of mixing equipment is whether to ensure the mixing proportion accuracy of aggregate, powder, water and other materials. Wbc300 stabilized soil plant mixing equipment is used in this bid section. The equipment adopts electromagnetic speed regulation system, which can better ensure the mixing ratio of various materials, uniform mixing and stable performance.
嚴格控制水泥用量
Strictly control the amount of cement
水泥用量過少，水泥穩定土的施工質量得不到保證；用量太大不經濟，而且會增加和擴大基層裂縫，從而在瀝青面層造成相應的反射裂縫。因此，必須嚴格控制水泥用量，做到經濟合理，精益求精，確保工程質量。
Too little cement is used, and the construction quality of cement stabilized soil can not be guaranteed; It is uneconomical to use too much, and it will increase and expand the cracks in the base course, resulting in corresponding reflection cracks in the asphalt surface course. Therefore, the cement consumption must be strictly controlled to achieve economic rationality, keep improving and ensure the project quality.
混合物的水分控制
Moisture control of mixture
在工廠拌合現場，后院的專職測試人員會在上午、中午和下午分別測量各種骨料的含水率，根據根據施工配合比設計的最佳含水率指標，結合氣溫，當天的濕度和運輸距離。
At the factory mixing site, full-time testers in the backyard will measure the moisture content of various aggregates in the morning, noon and afternoon respectively. According to the best moisture content index designed according to the construction mix proportion, combined with the temperature, humidity and transportation distance of the day.
這種情況決定了混合混合物時要使用的水量。前院負責測試壓實度的專職測試人員在攤鋪成型混合料的過程中也及時測量混合料的含水量，并指導壓路機及時碾壓，所以盡量在最佳含水率條件下滾動，盡量避免。
This determines the amount of water to be used when mixing the mixture. The full-time tester in charge of testing the compactness in the front yard also measures the water content of the mixture in time during the paving of the formed mixture and guides the roller to roll in time. Therefore, try to roll under the condition of the best water content and avoid it as much as possible.
因含水量過大而產生“彈性”和“波浪”現象，混合料可能達到密度和強度，增加混合料的干縮，使結構層容易出現干縮裂縫；或由于含水量低，使混合料容易松散，不易卷成形狀，也影響混合料可能的密度和強度。因此，只有嚴格按照規范施工，加強各個施工環節的質量控制，才能保證施工質量。
The phenomenon of "elasticity" and "wave" due to excessive water content, the mixture may reach density and strength, increase the dry shrinkage of the mixture, and make the structural layer prone to dry shrinkage cracks; Or due to low water content, the mixture is easy to loose and not easy to roll into shape, which also affects the possible density and strength of the mixture. Therefore, the construction quality can be guaranteed only if the construction is carried out in strict accordance with the specifications and the quality control of each construction link is strengthened.
減少混合物的離析
Reduce segregation of mixture
混合物的運輸應避免車輛碰撞。氣溫高、運輸距離長時，應蓋好氈布，以防水分過度流失。攤鋪和碾壓時，攤鋪系數在1.3∽1.5之間，濟南水穩料施工中必須貫徹“低不刮”，所有建設項目應在水泥終凝時間前完成。滾壓后立即進行密實度測試，如果測試結果不符合標準，重新滾壓。
The transportation of the mixture shall avoid vehicle collision. When the temperature is high and the transportation distance is long, the felt cloth shall be covered to prevent excessive loss of water. During paving and rolling, the paving coefficient shall be between 1.3 and 1.5. The "low without scraping" must be implemented in the construction of water stabilized materials in Jinan, and all construction projects shall be completed before the final setting time of cement. The compactness test shall be carried out immediately after rolling. If the test result does not meet the standard, it shall be rolled again.
濟南水穩料施工時注意事項就講解到這里完畢了，當然還有很多方面的事項以及細節需要大家去認真操作，更多信息獲取您可以關注我們的網站m.seatostar.com。
This is the end of the explanation of the precautions for the construction of water stabilized materials in Jinan. Of course, there are many matters and details that need to be carefully operated. For more information, you can pay attention to our website m.seatostar.com com。
公司地址：濟南市商河縣賈莊鎮民營經濟創業園
公司名稱:永誠廣建公路材料（山東）有限公司 
備案號：